Non-oxidative coupling of methane is a promising route to obtain ethylene directly from natural gas. We synthesized siliceous [Fe]zeolites with MFI and CHA topologies and found that they display high selectivity (>90 % for MFI and >99 % for CHA) to ethylene and ethane among gas-phase products. Deactivated [Fe]zeolites can be regenerated by burning coke in air. In situ X-ray absorption spectroscopy demonstrates that the isolated Fe³⁺ centers in zeolite framework of fresh catalysts are reduced during the reaction to the active sites, including Fe²⁺ species and Fe (oxy)carbides dispersed in zeolite pores. Photoelectron photoion coincidence spectroscopy results show that methyl radicals are the reaction intermediates formed upon methane activation. Ethane is formed by methyl radical coupling, followed by its dehydrogenation to ethylene. Based on the observation of intermediates including allene, vinylacetylene, 1,3-butadiene, 2-butyne, and cyclopentadiene over [Fe]MFI, a reaction network is proposed leading to polyaromatic species. Such reaction intermediates are not observed over the small-pore [Fe]CHA, where ethylene and ethane are the only gas-phase products.

Hydrogenation of levulinic acid to γ-valerolactone is a key reaction in the valorization of carbohydrates to renewable fuels and chemicals. State-of-the-art catalysts are based on supported noble metal nanoparticle catalysts. We report the utility of a bimetallic Fe-Re supported on TiO₂ for this reaction. A strong synergy was observed between Fe and Re for the hydrogenation of levulinic acid in water under mild conditions. Fe-Re/TiO₂ shows superior catalytic performance compared to monometallic Fe and Re catalysts at similar metal content. The hydrogenation activity of the bimetallic catalysts increased with Re content. H₂-TPR, XPS, XANES, EXAFS, Mössbauer spectroscopy, TEM, and low-temperature CO IR spectroscopy show that the bimetallic catalysts contain metallic Re nanoparticles covered by FeO_x species and small amounts of a Fe-Re alloy. Under reaction conditions, the partially reduced surface FeO_x species adsorb water and form Brønsted acidic OH groups, which are involved in dehydration of reaction intermediates. Under optimized conditions, nearly full conversion of levulinic acid with a 95 % yield of γ-valerolactone could be achieved at a temperature as low as 180 °C in water at a H₂ pressure of 40 bar.

Liu et al. recently reported their results on coconversion of methane and methanol at 973 K over a typical methane dehydroaromatization (MDA) catalysts, Mo/HZSM-5.1 In this work, the authors claimed that adding a small amount of methanol to a methane feed led to more than two times higher methane conversion, substantially higher xylene and toluene selectivities (i.e., combined ca. 80%, nearly an order of magnitude increase as compared to experiments without methanol), and improved catalyst stability to such an extent that no deactivation was observed during 60 h on stream. If reproducible, this result would be a significant achievement, because formation of coke in the MDA reaction has been considered inevitable hitherto. To support their experimental data, Liu et al. carried out a thermodynamic analysis, whose results were in good agreement with their experimental findings.

Non-oxidative methane dehydroaromatization is a promising reaction to directly convert natural gas into aromatic hydrocarbons and hydrogen. Commercialization of this technology is hampered by rapid catalyst deactivation because of coking. A novel approach is presented involving selective oxidation of coke during methane dehydroaromatization at 700 °C. Periodic pulsing of oxygen into the methane feed results in substantially higher cumulative product yield with synthesis gas; a H₂/CO ratio close to two is the main side-product of coke combustion. Using ¹³C isotope labeling of methane it is demonstrated that oxygen predominantly reacts with molybdenum carbide species. The resulting molybdenum oxides catalyze coke oxidation. Less than one-fifth of the available oxygen reacts with gaseous methane. Combined with periodic regeneration at 550 °C, this strategy is a significant step forward, towards a process for converting methane into liquid hydrocarbons.

In applying a multi-scale spectroscopic and computational approach, we demonstrate that the synthesis of stacked zeolite silicalite-1 nanosheets, in the presence of a long-tail diquaternary ammonium salt surfactant, proceeds through a pre-organised phase in the condensed state. In situ small-angle X-ray scattering, coupled to paracrystalline theory, and backed by electron microscopy, shows that this phase establishes its meso-scale order within the first five hours of hydrothermal synthesis. Quasi in situ vibrational and solid-state NMR spectroscopy reveal that this meso-shaped architecture already contains some elementary zeolitic features. The key to this coupled organisation at both micro- and meso-scale, is a structure-directing agent that is ambifunctional in shaping silica at the meso-scale whilst involved in molecular recognition at the micro-scale. The latter feature is particularly important and requires the structure-directing agent to reside within the silica matrix already at early stages of the synthesis. From here, molecular recognition directs stabilization of precursor species and their specific embedding into a lattice, as shown by force-field molecular dynamics calculations. These calculations, in line with experiment, further show how it is possible to subtly tune both the zeolite topology and aspect ratio of the condensating crystals, by modifying the headgroup of the structure-directing agent.