This study aimed at evaluating the nitrous oxide (N2O) emissions from membrane bioreactors (MBRs) for wastewater treatment. The study investigated the N2O emissions considering multiple influential factors over a two-year period: (i) different MBR based process configurations; (ii) wastewater composition (municipal or industrial); (iii) operational conditions (i.e. sludge retention time, carbon-to-nitrogen ratio, C/N, hydraulic retention time); (iv) membrane modules. Among the overall analysed configurations, the highest N2O emission occurred from the aerated reactors. The treatment of industrial wastewater, contaminated with salt and hydrocarbons, provided the highest N2O emission factor (EF): 16% of the influent nitrogen for the denitrification/nitrification-MBR plant. The lowest N2O emission (EF = 0.5% of the influent nitrogen) was obtained in the biological phosphorus removal-moving bed-MBR plant likely due to an improvement in biological performances exerted by the co-presence of both suspended and attached biomass. The influent C/N ratio has been identified as a key factor affecting the N2O production. Indeed, a decrease of the C/N ratio (from 10 to 2) promoted the increase of N2O emissions in both gaseous and dissolved phases, mainly related to a decreased efficiency of the denitrification processes.@en

In this study a University of Cape Town (UCT) Integrated Fixed Film Activated Sludge (IFAS) Membrane BioReactor (MBR) wastewater treatment plant was monitored in terms of nitrous oxide (N₂O) emissions. The short term effect on the N₂O emission due to the influent carbon-to-nitrogen (C/N) ratio variation (C/N ratios of 2, 5 and 10 gCOD/gN) was evaluated. Since in a previous study, the effect of the C/N ratio was studied in the same system without biofilm (UCT-MBR configuration) the main aim here was to investigate the role of biofilms on N₂O emissions. Under all the investigated C/N ratios, the N₂O fluxes and the average emission factors were lower than that of previous studies with no biofilm presence. The total average N₂O emission was 0.5% of the influent nitrogen with biofilm (IFAS system) and 3.5% without biofilm. This result emphasizes the potential role of the biofilms in attenuating the N₂O emissions especially in the case of stress conditions (i.e., low C/N influent ratios). An increase of N₂O flux from the anoxic reactor (till 28 mgN₂O m^-2h^-1) occurred at the lowest influent C/N tested (2 gCOD/gN - phase III). At C/N equal to 2 gCOD/gN the anoxic reactor was the main source of N₂O, contributing 45% of all produced N₂O. This result was attributed to an incomplete denitrification caused by a lack of organic carbon and a slight increase of dissolved oxygen concentration.

@en